RE: 1 cylinder down - final update
john leonard
jlmdx at hotmail.com
Thu Mar 27 11:27:06 PDT 2014
BACK IN BUSINESS
-Reseated the ignition wires to the plug
ends
-Removed and cleaned all of the carbs (more
thoroughly than the first time)
-Cleaned the air filter
-Changed the oil & filter, gas &
filter, and spark plugs
-Added fresh gas and a few ounces of Sea
Foam and idled it for while
Since then, I've been riding it and
it's back running strong.
During this, I also noticed at the
bottom of the air box there is a "body-breather" / PVC
that sends unburnt combustion back into the cylinders up 4 separate
tubes within the air box bypassing the air filter. But that
open-bottomed breather assembly is glued to the bottom of the air box
and the glue no longer held so engine oil ended up on the air filter.
I've been noticing the oil for years and simply replaced the air
filter a couple of times. This time I cleaned and epoxied the
junction box so oil won't foul the box and filter again.
Thank you all for the comments and suggestions!, john
> From: sirdondiego at outlook.com
> Subject: RE: 1 cylinder down - update
> Date: Mon, 17 Mar 2014 00:37:18 -0500
> To: JLMDX at hotmail.com
>
> Don't waste your time putting a filter on the snorkle that points down in the airbox. That peice of foam is open on the end and is there for sound deadening only. I wonder if the disintigrated pieces are clogging up your air filter. Clogged pilot jets will cause problems too.Good luck!
>
> > From: jlmdx at hotmail.com
> > Subject: RE: 1 cylinder down - update
> > Date: Sun, 16 Mar 2014 14:15:42 -0400
> > To: Sirdondiego at outlook.com
> >
> > Timothy: I didn't realize I'd need to rejet for pods. I'll get the pods eventually and chuck that air box, but for now I don't want to introduce jet changes too until it runs smoothly.
> >
> > It sat for 24 hours in the Prime position and no leaking - so I think the float pin is back in business.
> >
> > Ped: It doesn't look like the plug cables are replaceable without buying the coils too @ $70 * 2. That's going to wait until I've put everything back together and see how it runs with the new plugs.
> >
> > Steve: I tried running the motor with the air injection tube plugged and unplugged - I don't notice a difference.
> >
> > I did notice on the throat side of the air intake box there is another filter in there. The fiche simply calls it a duct, but it's wrapped with a foam filter tape that was 50% disintegrated. I don't think it's even replaceable without removing the air box. I'm going to wrap that duct with a fiberglass filter I have laying around.
> >
> > Thanks all, john
> >
> >
> >
> > > Date: Sun, 16 Mar 2014 07:35:12 +0100
> > > From: gpz1100abs at gmail.com
> > > Subject: Re: 1 cylinder down - update
> > > To: JLMDX at hotmail.com
> > >
> > > You may be on the right track suspecting the ignition. Some years ago a
> > > German friend of mine experienced intermittent bad running as well. He
> > > went through just as much as you've done without getting to the bottom
> > > of the problem. As a last resort he changed the ignition cables and this
> > > did the trick. He said he got a completely new bike, running so smoothly
> > > like never before. Might be worth a try if nothing else works.
> > >
> > > Ped
> > > '96 "Black Stealth" GPZ
> > > Denmark
> > >
> > > Den 16-03-2014 02:56, john leonard skrev:
> > > > I've checked a few things on my '96.I purchased a compression gauge and tested the cylinders. They appear about equal. 2 @150 psi and 2 @ 160 psi. I removed the air box (for good), and intend to install pod filters and a crankcase filter.I cleaned out #3's bowl and float pin (the one that flooded) and sprayed carb cleaner in all the intakes. I didn't remove/adjust the jets. I cleaned the spark plugs again; they all show about the same resistance on a meter. I put the tank and carbs back on and it's still not running well and stalls if I give it any gas, but I think I need pods in place.I'm beginning to think the ignition is at fault. As I mentioned in my last post, the engine was missing big-time a few weeks ago (before the hydro lock) then it magically starting working again after sitting for a day to two.
> > > > So here's what's on order. 4 new plugs, 4 pods, 1 crank filter, and new Service Manual (my old one went missing). I'll test the ignition and the cables once I find out how that's done.
> > > > john
> > > >
> > > >
> > > > ______________________________________________________________________
> > > > GENERAL GPZList MAILING LIST INFORMATION:
> > > > This is from the GPZList mailing list. GPZList at micapeak.com
> > > > http://micapeak.com/mailman/listinfo/gpzlist
> > > > You subscribed to this mailing list. Therefore, you solicited all
> > > > mail that you receive from this list. Therefore, ANY mail that you
> > > > receive from this list is, by definition, NOT Spam, and if you report
> > > > it as such, you are violating the micapeak.com terms of service.
> > > >
> > > > To unsubscribe, you may send email to gpzlist-unsubscribe at micapeak.com
> > > > ______________________________________________________________________
> > > > YOUR PERSONAL SUBSCRIBER OPTIONS:
> > > > Unsubscribe or choose new options at
> > > > http://micapeak.com/mailman/options/gpzlist/gpz1100abs%40gmail.com
> > > > You are subscribed at the email address gpz1100abs at gmail.com
> > > > ______________________________________________________________________
> > > >
> > >
> > >
> > > --
> > >
> > > *Jens L. Pedersen*
> > > IFR Procedure Designer
> > >
> > > ------------------------------------------------------------------------
> > >
> > > Tactical Air Command Denmark
> > > Herningvej 30,
> > > DK-7470 Karup J
> > > DENMARK
> > > Phone: +45 9710 1550 Ext. 6244
> > > Mobile: +45 3013 0116
> > > Email: ftk-fli at mil.dk
> > >
> > > ______________________________________________________________________
> > > GENERAL GPZList MAILING LIST INFORMATION:
> > > This is from the GPZList mailing list. GPZList at micapeak.com
> > > http://micapeak.com/mailman/listinfo/gpzlist
> > > You subscribed to this mailing list. Therefore, you solicited all
> > > mail that you receive from this list. Therefore, ANY mail that you
> > > receive from this list is, by definition, NOT Spam, and if you report
> > > it as such, you are violating the micapeak.com terms of service.
> > >
> > > To unsubscribe, you may send email to gpzlist-unsubscribe at micapeak.com
> > > ______________________________________________________________________
> > > YOUR PERSONAL SUBSCRIBER OPTIONS:
> > > Unsubscribe or choose new options at
> > > http://micapeak.com/mailman/options/gpzlist/jlmdx%40hotmail.com
> > > You are subscribed at the email address JLMDX at hotmail.com
> > > ______________________________________________________________________
> >
> > ______________________________________________________________________
> > GENERAL GPZList MAILING LIST INFORMATION:
> > This is from the GPZList mailing list. GPZList at micapeak.com
> > http://micapeak.com/mailman/listinfo/gpzlist
> > You subscribed to this mailing list. Therefore, you solicited all
> > mail that you receive from this list. Therefore, ANY mail that you
> > receive from this list is, by definition, NOT Spam, and if you report
> > it as such, you are violating the micapeak.com terms of service.
> >
> > To unsubscribe, you may send email to gpzlist-unsubscribe at micapeak.com
> > ______________________________________________________________________
> > YOUR PERSONAL SUBSCRIBER OPTIONS:
> > Unsubscribe or choose new options at
> > http://micapeak.com/mailman/options/gpzlist/sirdondiego%40outlook.com
> > You are subscribed at the email address Sirdondiego at outlook.com
> > ______________________________________________________________________
>
> ______________________________________________________________________
> GENERAL GPZList MAILING LIST INFORMATION:
> This is from the GPZList mailing list. GPZList at micapeak.com
> http://micapeak.com/mailman/listinfo/gpzlist
> You subscribed to this mailing list. Therefore, you solicited all
> mail that you receive from this list. Therefore, ANY mail that you
> receive from this list is, by definition, NOT Spam, and if you report
> it as such, you are violating the micapeak.com terms of service.
>
> To unsubscribe, you may send email to gpzlist-unsubscribe at micapeak.com
> ______________________________________________________________________
> YOUR PERSONAL SUBSCRIBER OPTIONS:
> Unsubscribe or choose new options at
> http://micapeak.com/mailman/options/gpzlist/jlmdx%40hotmail.com
> You are subscribed at the email address JLMDX at hotmail.com
> ______________________________________________________________________
More information about the GPZList
mailing list